神狐牌HLQ9401GFL型粉粒物料运输半挂车

粉粒物料运输车

粉粒物料运输车又称散装水泥车，由专用汽车底盘、散装水泥车罐体、气管路系统、自动卸货装置等部分组成。适用于粉煤灰、水泥、石灰粉、矿石粉、颗粒碱等颗粒直径不大于0.1mm粉粒干燥物料的散装运输。主要供水泥厂、水泥仓库和大型建筑工地使用，可节约大量包装材料和装卸劳动。

底盘

　　可选择东风底盘、解放底盘、重汽斯太尔底盘、江淮

粉粒物料运输车

底盘，根据实际需求，用户可自选底盘。

罐体

　　粉粒物料车罐体主要由筒体、罐体上端给进料口、流态化床、出料管总成、进气管及其它附件组成。

　　罐体顶部装有两个或三个给进料口。

检测

　　水泥试验塔

管路系统

散装水泥车前、后气室各设一根进气管，通过球阀可分别实现同时开启和单独控制的功能。

　　系统工作原理如下:工作动力从汽车变速箱中引出,通过传动装置驱动空压机，产生的压缩空气经控制管路进入气室内,使罐内粉粒物料产生流态化现象。当压力达到0.196Mpa时，打开出料蝶阀，实现卸料。

用户指南

　　1、驾驶散装水泥车时不要超速、超压运行，超速、超压会严重损坏空压机。本机最高转速见主要技术参数表，工作压力为0.2MPa。

　　2、不要快速启动或停止空压机，而应缓慢增速或减速，否则，冲压力会损坏空压机。

　　3、不要改变空压机的旋转方向，否则，油泵不供油会严重损坏机器。

　　4、不要在减压前停止空压机，否则，粉粒物料可能倒流进气缸，造成空压机严重损坏。

　　5、开机前需检查油标。油位不得低于油标下限；需经常检查油泵是否供油，若不供油，应立即停机检查，否则，缺油会严重损坏空压机。

　　6、要按期更换润滑油。新机使用30小时后，排出曲轴箱里的油，清洁曲轴箱内部及滤油网，然后换油。以后每年照上述换油一次。

　　7、要检查、清洁滤油网。正常情况每季度检查、清洁一次，如果机器使用率高，应一个月检查、清洁一次。

　　8、本机使用的润滑油为CD40柴机油。禁止不同牌号的润滑油混用，否则润滑油变质会影响润滑效果。

　　9、每工作30小时要保养、清洁空气滤芯。转动滤芯的同时，用压力小于0.6MPa的压缩空气由内向外吹。保养五次后，请更换新滤芯。严禁用油或水清洗滤芯。

技术标准

　　QC/T 560-1999

工作原理

　　利用本车动力驱动空气压缩机， 将压缩空气经管道送入密封罐体下部的气室，使气室液态化床上的粉粒体悬浮成流态状，当罐内压力达到额定值时，打开卸料阀，流动化物料通过管道流动而进行输送。

基本结构

　　1.汽车底盘。

　　2.取力器。

　　3.空气压缩机。

　　4.空气管道。

　　5.罐体。

　　6.卸装料装置。

Unit name：Hubei Heli Special Automobile Manufacture Co.,Ltd

Address：No.1st,XingGuang Industrial Park north suburb, Suizhou City, Hubei province, China

Postal Code：441300

Contact person：Evan Xia Mobile:+8618971790999

Tel:+86-0722-3321836

Fax:+860722-3328812

http://www.chinahlqc.com http://chinahlqc.cn.alibaba.com/

E-mail:chinahlqc@163.com

QQ:1480073442

ID:chinahlqc

MSN:xlx2182@hotmail.com

skepy:xlx2182

Hubei Heli Special Automobile Manufacture Co., Ltdis a special purpose vehicle manufacturer that has the capacity of self-research and development.

     The main products arewater truck, fuel tanker, fecal suction truck, sewage suction truck, concrete mixer truck, dump truck, high-altitude operation truck, self-lOAding garbage truck, garbage compactor truck, sealed garbage truck, bulk cement truck, low plate semi-trailer, grid-type semi-trailer, van semi-trailer, fence semi-trailer, semi-trailer, Bulk cement transportation semitrailer, oil semi-trailer, container Semi-trailer, chemical liquid transport semi-trailer, ect more than 300 types in total.

     The company is located in Suizhou, a city well known as the hometown of Emperor Yan, the legendary god of farming in ancient China. 195 km away from Wuhan in the east, 298 km from Shiyan in the west, the Wuhan-Shiyan highway meets here in the south, and State 316 Highway cross main areas of Suizhou in the north; it’s one of the largest base of the special purpose automobile refitting production. The company was formerly Suizhou Tian Feng Automobile Co. With great support from the government, former Li Qiang Special Purpose Vehicle Manufacturing Co. and Suizhou He Li Truck & Trailer Manufacturing Co. mergered together to be a new company named Hubei He Li Special Purpose Automobile Manufacturing Co., Ltd.

     Since the new company founded, we reserved most backbone technicians from the old plant who are with ability, experience, and innovation. As well we have bought more than 300 sets of advanced equipments, including large CNC bending machine, underwater plasma cutting machine, hydraulic machine, forging Machine, tank molding coiling machine, arc welding machine, X-ray detection machine, ect. The company has more than 800 professional workers, among which, more than 100senior and intermediate technicians, more than 400 senior and intermediate skilled workers, 20 new products engineers, and more than 100 support personnel. We have a yearly production capacity of more than 5000 sets of refitting vehicles.

     The company committed to the pursuit of technology research and application of safety, environmental protection, high efficiency, energy conservation, and automation. The products are evaluated to be "Chinese consumers’ satisfactory brand", “National band with good quality and satisfactory service”, “Well-known brand in Hubei”; and the company is praised as an “enterprise with integrity to comply with the contract”; listed as banking credit “AAA” grade; enterprise with new high technologies’; pass ISO9001 certification and China Compulsory Certification. Meanwhile we are trying to carry out TS16949, ISO14000, ect Certification systems.

     In 2006, the company set up special network marketing department and on-line sales center. After effort of one year, our marketing has been developing greatly and has business in foreign countries such as Russia, Denmark, Georgia,Kazakhstan, Algeria, Australia, Bahamas, ect.

      After the 17th People's Congress, the company has been positively complied with the policies of the Party; adapted to the new change of social situation and economic development trends; further expand the joint-venture to bring in capital and technology; as well as increases technological transformation to improve exiting products on scale and level, which is to strengthen our brand.

     We look forward to your joining in our common cause with full passion and enthusiasm, to cooperate and develop together with honesty.

湖北合力专用汽车制造有限公司为欧曼、陕汽、东风、一汽大委企业，专业生产销售油罐车、水泥罐车、搅拌车、随车吊、清障车、洒水车、吸污车、除雪车、吸尘车、扫路车、高压清洗车、自卸车、散装饲料车和半挂车，详情登录http://www.chinahlqc.comhttp://chinahlqc.cn.alibaba.com/

诚招国内国外代理商

免责声明：本文所用视频、图片、文字如涉及作品版权问题，请第一时间告知，我们将根据您提供的证明材料确认版权并立即删除内容。